Escea ST900 Manuel d'installation

630167_5_Manual_Installation_US_R-emotion ST900 Direct Vent Gas Fireplace Installation Manual NORTH AMERICA EDITION Manu

630167_5_Manual_Installation_US_R-emotion 11.0 Removing the Firebox Glass: Pull the four hooks shown below towards you and then away from the gl

630167_5_Manual_Installation_US_R-emotion 12.0 Installing the Flue System: Ensure all flue components are Simpson Duravent Direct Vent Pro 5” x 8,

630167_5_Manual_Installation_US_R-emotion 12.5 Vertical Only Flue Diagram: Use this diagram to

630167_5_Manual_Installation_US_R-emotion 12.6 Horizontally Terminating Flue Diagram: Use this

630167_5_Manual_Installation_US_R-emotion 12.7 Vertically Terminating flue with a Horizontal Offset:

630167_5_Manual_Installation_US_R-emotion 12.8 Standard Flueing Configurations: The following flue components are available from your escea distri

630167_5_Manual_Installation_US_R-emotion 12.9 Locating the Flue Terminal: The flue terminal must be located using the information given in the fol

630167_5_Manual_Installation_US_R-emotion 12.10 Supporting the flue system: Wall straps are required to fix the flue system in place for each ins

630167_5_Manual_Installation_US_R-emotion 13.0 Fitting the Flue Restrictor: If your flueing configuration requires that you fit a flue restrictor

630167_5_Manual_Installation_US_R-emotion 14.0 Converting to Propane Gas: Where a conversion to propane gas is needed, the following steps should

630167_5_Manual_Installation_US_R-emotion Important: The appliance shall be installed in accordance with; • This installation instruction bookle

630167_5_Manual_Installation_US_R-emotion Now, put the gas data (Propane sticker shown) sticker supplied in the conversion kit in onto the dataplate

630167_5_Manual_Installation_US_R-emotion 15.0 Placing the Fuel Bed Media: Your ST900 Gas fireplace will be supplied with a Fuel Bed kit. Follow

630167_5_Manual_Installation_US_R-emotion 16.0 Re-fitting the Glass Assembly To re-fit the glass assembly, place the bottom of the glass assembly

630167_5_Manual_Installation_US_R-emotion 17.0 Checking Operating Pressure: WARNING: The regulator that is supplied with the fireplace MUST NOT

630167_5_Manual_Installation_US_R-emotion 19.0 Commissioning the Fire: After the cladding and finishing processes are completed, the gasfitter mus

630167_5_Manual_Installation_US_R-emotion 3. The ST900 fascia uses these four hooks for attaching to the fire. Do this by lining up the fascia hoo

630167_5_Manual_Installation_US_R-emotion 2. Install the Heat Deflector to the top of the fireplace using the 3x supplied screws with the Heat

630167_5_Manual_Installation_US_R-emotion 19.3 Cleaning the ST900 Fascia: The fascia must be cold before starting any form of maintenance or clea

630167_5_Manual_Installation_US_R-emotion 20.0 Operating Instructions:

630167_5_Manual_Installation_US_R-emotion Note: If this is the first time running the ST900 the air will need to be purged from the gas lines. To do

630167_5_Manual_Installation_US_R-emotion Note: THERE ARE A FEW THINGS TO CONSIDER BEFORE INSTALLATION • Cavity Dimensions and Clearances •

630167_5_Manual_Installation_US_R-emotion 20.2 Switching off the ST900: To turn off the fire, push the OFF button, to shut down the gas flow to th

630167_5_Manual_Installation_US_R-emotion > Program mode: By default the program mode is not enabled. To enable program mode, enter configuratio

630167_5_Manual_Installation_US_R-emotion 20.4 Changing the display from Celsius to Fahrenheit: Go into Menu → Adjust menu → Unit. Press middle bu

630167_5_Manual_Installation_US_R-emotion 20.8 Pairing the Remote to the Control Unit: Install batteries to the battery pack and after a while the

630167_5_Manual_Installation_US_R-emotion 20.9 Initial configuration: To enter the configuration menu, press the OFF button on the remote control

630167_5_Manual_Installation_US_R-emotion 21.0 Sounds and Smells: Note: Each time the fireplace is lit from cold the glass will fog up with con

630167_5_Manual_Installation_US_R-emotion 22.0 Annual Service Check: The ST900 Fireplace should be serviced annually to ensure it continues to op

630167_5_Manual_Installation_US_R-emotion 24.0 Appendix A: Points to note when planning the Installation of the Escea DV flue: - This flue system

630167_5_Manual_Installation_US_R-emotion 24.1 Appendix B: 24.2 Appendix C: Clearances to Combustible Surfaces:

630167_5_Manual_Installation_US_R-emotion 24.3 Appendix D: Replacement Parts: Replacement parts for the ST900 gas fireplace are available from all

630167_5_Manual_Installation_US_R-emotion Contents: 1.0 Product Description 2.0 Creating the Cavity 3.0

630167_5_Manual_Installation_US_R-emotion 25.0 WARRANTY TERMS & CONDITIONS: LIMITED WARRANTY: Provided that the Product is installed as per ESC

630167_5_Manual_Installation_US_R-emotion 6. ESCEA is not responsible for damage arising from failure to follow instructions for the product's

630167_5_Manual_Installation_US_R-emotion

630167_3_Manual_Service_ST900_US_R‐emotion

630167_3_Manual_Service_ST900_US_R‐emotion

630167_3_Manual_Service_ST900_US_R‐emotion15.0 Troubleshooting Usethefollowingtroubleshootingcharttodiagnoseandfault‐findoperationaliss

630167_3_Manual_Service_ST900_US_R‐emotion12.0 Re‐assemble Oncetheserviceworkiscomplete,thefireshouldbere‐asse mbledbyreversingth

630167_3_Manual_Service_ST900_US_R‐emotion7.0 CleanPilotandMainBurnerJets: Withtheburnerremovedtheburnerjetisnowaccessible.Remov

630167_3_Manual_Service_ST900_US_R‐emotion5.0 RemoveControlTray[ifrequired]: Ifthethermocoupleneedstobereplaced,ortheControlTray

630167_3_Manual_Service_ST900_US_R‐emotion4.0 RemoveFireboxContents: Ensurethefireboxcontentshavecooleddowncompletely beforeattemp

630167_5_Manual_Installation_US_R-emotion 1.0 Product Description: The Escea ST900 decorative gas fireplace is designed to be built in

630167_3_Manual_Service_ST900_US_R‐emotion1.0 IsolatePowerandGasSupply:BeforeanyserviceandmaintenanceworkisdoneontheST900,thegas

630167_3_Manual_Service_ST900_US_R‐emotionContents:  DIS‐ASSEMBLY‐ Isolatepowerandgassupply ‐ 1.0‐Removefascia‐2.0‐Remo

630167_3_Manual_Service_ST900_US_R‐emotion ST900 Direct Vent Gas Fireplace Service Guide NORTH AMERICA EDITION Important • It is re

630167_5_Manual_Installation_US_R-emotion 2.0 Creating the Cavity: The dimensioned drawing below shows the size of opening that must be created t

630167_5_Manual_Installation_US_R-emotion 2”2”2”20”4”4”2”2”2”2”MantleMantleRecessed TVFlush TV with small mantleMantle above fire Protruding fire20”

630167_5_Manual_Installation_US_R-emotion 5.2 Non-Combustible Mantle Clearances: If the entire installation (mantle, wall and cavity) is construct

630167_5_Manual_Installation_US_R-emotion 8.0 Connecting the Gas Pipe: An accessible inline isolation or service valve must be fitted and pipe ru